Oil Burner, Boiler Cleaning, Heat Repair, Water Heater Repair Nassau LI NY

Boiler Cleaning, Heat Repair, Water Heater Repair Nassau NY, Nassau Heating Repairs, Heat Repair, Boiler Repair. Run Out Of Oil? Emergency Oil Delivery (8-10 gallons), Bleed out and change Filter if needed. Residential Boiler service, No heat, Feul Oil Heat, Oil Burner Repair, Thermostat replacement, Circulator replacement, Pipe Repairs, Hot Water Repair, Hot Water heater replacement, Oil Tank Removal, Oil Tank Replacement. Help is on the way. Emergency 10 Gallon Oil Delivery and Boiler Start up..
1 (516) 477-4545 Cell
http://www.RepairNewYork.com
VISUAL INSPECTION
1 Check for significant corrosion on the boiler’s outer
sheetmetal, its cast-iron sections, flue, electrical
controls, nearby piping and components.
2 Check above-ground oil tanks and lines for leakage.
3 The boiler should have an oil shutoff valve positioned
before the fuel filter cartridge. Install one if needed,
preferably one that cuts off fuel flow in the event of
a fire. Replace compression fittings on oil lines with
flare fittings.
4 Make sure the burner’s air inlets and shutters are free
of lint and dust.
5 Open the boiler top or look through the inspection
port to check for cracks in the firebox or on the target
wall (the fire clay box or wall that the burner fires into
or against).
6 Remove the burner electrode assembly. Check the
electrodes and their porcelains. Adjust the electrode
spacing.
7 Check the transformer bushings, springs and ignition
wiring.
8 Check the burner motor shaft for end play. Lubricate
the burner motor and circulators if they are not
permanently lubricated types.
9 Check the draft regulator for free movement.
CLEANING
1 Remove the boiler flue sections. Brush and vacuum
them clean.
2 Brush clean the surfaces of the boiler sections.
3 Clean the cadmium-sulfide flame sensor (the cad-cell
eye), check its alignment and check its wires.
4 Clean the burner air tube.
OPERATION (ADJUSTMENT AND ANALYSIS)
1 Remove the limit control housing and check the
temperature settings of the high-limit and low-limit
controls.
2 Fire the boiler and check gauge readings for correct
boiler water temperature and pressure. Adjust the
boiler controls to produce correct gauge readings.
3 Measure flue gas temperature and use a combustion
gas analyzer to read the percentage of combustion
chemicals (carbon dioxide and carbon monoxide).
Adjust the burner if needed.
4 Check the burner’s flame shape. Again, adjust the
burner to correct if necessary.
5 Check the pressure and the oxygen content of the
combustion gas over the fire.
6 Check the oil pump for leaks and perform a pressure
test.
7 Flip the boiler’s Emergency Switch while the boiler
is firing to check that it cuts off the boiler.
8 Adjust wall thermostat settings to check that the
boiler responds to them.
PARTS REPLACEMENT
1 Replace the fuel filter.
2 Replace the burner nozzle.
Lifes Messy, Clean It Up!
Licensed / Insured
NYNY
Hicksville, NY 11801
1 (516) 477-4545 Cell
1(516)9352662Machine
http://www.RepairNewYork.com
Nassau County New York
Nassau:
Albertson,Alden Manor, Atlantic Beach, Baldwin, Baldwin Harbor, Barnum Island, Baxter Estates, Bay Colony, Bay Park, Bayville, Bellerose, Bellerose Terrace, Bellmore, Bethpage, Biltmore Shores, Brookville, Carle Place, Cedarhurst, Centre Island, Cove Neck, East Atlantic Beach, East Garden City, East Hills, East Massapequa, East Meadow, East Norwich, East Rockaway, East Williston, Elmont, Farmingdale, Floral Park, Flower Hill, Franklin Square, Freeport, Garden City, Garden City Park, Garden City South, Glen Cove, Glen Head, Glenwood Landing, Great Neck, Great Neck Estates, Great NeckGardens, Great Neck Plaza, Green Acres, Greenvale, Harbor Green, Harbor Hills, Harbor Isle, Hempstead, Hempstead Gardens, Herricks, Hewlett, Hewlett Bay Park, Hewlett Harbor, Hewlett Neck, Hicksville, Hillside Manor, Inwood, Island Park, Jericho, Kensington, Kings Point, Lake Success, Lakeview, Lattingtown, LaurelHollow, Lawrence, Levittown, Lido Beach, Locust Grove, Locust Valley, Long Beach,Lynbrook, Malverne, Malverne Park Oaks, Manhasset, Manhasset Hills, Manorhaven, Massapequa, Massapequa Park, Matinecock, Meadowmere Park, Merrick, Mill Neck, Mineola, Munsey Park, Muttontown, Nassau Shores,New Cassel, New Hyde Park, North Bellmore, North Hills, North Lynbrook, North Massapequa, North Merrick, North New Hyde Park, North Valley Stream, North Wantagh, North Woodmere, Oceanside, Old Bethpage Old Brookville, Old Westbury, Oyster Bay, Oyster Bay Cove, Plainedge, Plainview, Plandome, Plandome Heights, Plandome Manor, Point Lookout, Port Washington, Port Washington North, Rockville Centre, Roosevelt, Roslyn, Roslyn Estates, Roslyn Harbor, Roslyn Heights, Russell Gardens, Saddle Rock, Saddle Rock Estates, Salisbury, Sands Point, Sea Cliff, Seaford, Searingtown, South Farmingdale, South Floral Park, South Hempstead, South Valley Stream, Stewart Manor, Strathmore, Syosset, Thomaston, Uniondale, University Gardens, Upper Brookville, Valley Stream, Wantagh, West Hempstead, Westbury, Westbury South, Wheatley, Williston Park, Woodbury, Woodmere, Woodsburgh